Plymouth, Minnesota
Durable PVC Roofing in Plymouth, MN
Wooded lots do something to a commercial flat roof that nobody warns you about. Along the office and restaurant buildings in Plymouth, leaf litter and needles wash to the drains, sit in the low spots, and mix with whatever the kitchen fan is putting out. PVC handles the grease part. The rest is drainage, and it is where most of these roofs actually fail.
Get your estimate today
Rated 5.0 from 217 Google reviews
- Licensed and insuredMinnesota exterior contractor
- 5.0 from 217 reviewsVerified on Google
- Storm and insurance workWe handle the claim with you
- Faith-based, locally ownedRefreshingly honest
Debris and standing water are the real enemy
A Plymouth business park roof gets serviced twice a year, if that, and in between the drains fill. Crews find strainers buried under a season of leaves, ponding in the same corner every visit, and a grease film from the exhaust fan bound up with organic debris into something that holds water against the seam. PVC survives that chemistry, which is exactly why owners here choose it, but no membrane survives water that never leaves. So the work is in the details: new drains and clamping rings where the old ones are rotted, tapered fill in the low spots, walk pads along the path service techs actually take to the rooftop units, and thicker membrane where limbs come close. For a clean roof with open sky above it, EPDM roofing is still a perfectly good membrane and we will say so.
PVC Roofing in Plymouth
What this buys you on a wooded site
Drains rebuilt, not just cleaned
Cast drains under two old roofs usually sit low and leak at the clamping ring. We reset them at the new membrane height with a proper sump, so water leaves through the drain instead of around it.
Walk pads where the service techs go
Rooftop units get visited by mechanical and exhaust cleaning crews all year, and boot traffic on cold membrane is how punctures start. We lay walk pad along the route they actually use.
Thicker membrane where limbs reach
On a lot with mature trees the roof takes branch drag and the occasional falling limb. A heavier reinforced sheet in those areas is worth specifying and it stops the calls about pinholes near the tree line.
Grease and leaf sludge shrugged off
Exhaust residue mixed with wet leaves turns into an acidic paste that eats asphalt and softens rubber. A welded PVC field takes it, which is why restaurant roofs out here keep theirs longer.
Every seam probed before we leave
Each lap gets checked with a hand probe before a section is called done, and questionable spots get cut open and rewelded. On a roof that ponds, an untested seam is where water gets in.
Interior finishes stay dry
Offices and clinics in these business parks have ceilings, casework and equipment underneath. The point of doing the flashing and drain work properly is that nothing downstairs finds out the roof was tired.
How we approach a business park roof
We show you the photos
Nobody wants to climb a ladder to check on a contractor. Every problem area we find gets photographed and walked through with you before the scope is written.
The quote itemizes the details
Drains, curbs, walk pad, tapered fill and edge metal are listed separately. On a cut-up roof those lines are most of the job, and you should be able to compare them bid to bid.
Maintenance advice with no upsell
Sometimes the honest answer is to clear the drains twice a year and look again in three. We will tell you that even though it means we do not sell a roof this season.
Kitchen and rooftop equipment coordinated
Fans and units have to come up or shut down while a curb is reflashed. We schedule that with your kitchen and your mechanical contractor so nobody is cooking with a fan off the roof.
We are the ones on the roof
The person who writes your scope is on site while the work happens. On a detail-heavy roof that matters, because the flashings are where a job is won or lost.
What people near Plymouth say
The crew arrived early and spread tarps all around the house to capture every bit of debris. By 3:00 PM, my entire roof was completely finished.
Hazel JamesRoof replacement, Minneapolis, MN Orange Exteriors fixed a minor leak that involved replacing flashing and a few shingles blown off our roof. Timely, quality work. Great ideas to keep our roof going long term.
Jim ThomasStorm damage repair From sales to construction crew to upper management, they helped make an insurance battle a breeze. This is the best contractor interaction I have ever had.
Jim NormanRoof replacement
Plymouth commercial roofing questions
What people in Plymouth ask us about this work. If yours is not covered, call and ask.
Do trees over our Plymouth office building damage a flat roof?
They shorten its life two ways. Leaves and needles clog drains, which leaves water standing where it should be moving, and branches abrade the membrane where they touch. PVC handles the water and the grease better than most, but we still add walk pad, drain strainers and heavier sheet near the tree line.
Will a new membrane stop water ponding on our roof?
Not by itself. Ponding is a slope and drain problem, and a new sheet laid over the same low spots will pond the same way. The fix is tapered insulation, a reset drain, or in some cases an added drain. We measure the low areas during the estimate and tell you which of those yours needs.
How long does a flat roof replacement take on a Plymouth business park building?
A single-tenant building of ordinary size is usually a matter of days once material is on site. What stretches it is the detail work: a cut-up roof with many curbs, drains and level changes takes longer than a plain field of the same area. Weather stops us too, since we will not leave a deck open under rain.
Have the drains and seams checked
Tell us which corner leaks and when it started. We will pull the strainers, probe the seams, check the low spots, and give you a free, no-obligation estimate for what the roof needs.
Get Your Free Exterior Estimate
Tell us what is going on with your roof, siding, windows, or gutters. We will take a look and give you a straight answer, including when the answer is that you can wait.
- Phone(612) 600-8529
- Emailadmin@orange-exteriors.com
- Office6600 City West Pkwy Suite 375, Eden Prairie, MN 55344
- HoursOpen 24 hours, Sunday to Saturday
Request your estimate
Rated 5.0 from 217 Google reviews