Andover, Minnesota
Straightforward PVC Roofing in Andover, MN
Two very different things come down on the low slope roofs at the retail edges of Andover, hot fryer vapor from the hood on one end and a season of oak litter on the other. Orange Exteriors welds PVC commercial roofing built for that mix: animal fat, solvent exhaust, wet leaf mats and the occasional falling limb, all landing on one continuous sheet.
Get your estimate today
Rated 5.0 from 217 Google reviews
- Licensed and insuredMinnesota exterior contractor
- 5.0 from 217 reviewsVerified on Google
- Storm and insurance workWe handle the claim with you
- Faith-based, locally ownedRefreshingly honest
Hot Fats, Oak Litter, One Flat Roof
Cooking oil is not inert. Vaporized fryer exhaust condenses on whatever sits downwind of the fan, and on an asphalt or rubber sheet those fats slowly soften the surface and open the laps around the curb. Andover's commercial tenants produce exactly that load: pizza and burger kitchens in the strip retail, a bakery oven venting all morning, auto and small engine shops pushing lubricant mist out a sidewall, and a few bays running degreasers past a rooftop unit. PVC answers it with chemistry. The sheet is welded lap to lap, so there is no adhesive line for oil to work into, and the compound holds up against fats that would ruin EPDM roofing within a few seasons under the same fan. We still install and repair rubber where it belongs, on clean office and dry warehouse decks, but never under a hood.
PVC Roofing in Andover
What a Welded Roof Does for an Andover Shop
Fryer Fallout Beads and Runs Off
Hood fallout sits on the surface instead of soaking into it, so the sheet keeps its flexibility downwind of the curb. That patch of roof, three or four feet past the fan, is exactly where asphalt and rubber give up first.
A Falling Limb Does Not Split It
Oak wilt keeps killing bur and northern pin oaks over these rooflines, and every windstorm brings the dead wood down. Reinforced PVC carries real puncture and tear strength, so a limb strike leaves a repairable wound rather than an open deck.
Fire Ratings You Can Hand Over
PVC assemblies carry strong fire performance ratings, which matters over a commercial kitchen more than almost anywhere else. We deliver the assembly paperwork your insurer and the city inspector will ask for before the building reopens.
Leaf Mats Never Reach the Sump
Oak litter blankets these roofs every October and dams the drains. A smooth welded surface lets debris travel instead of catching on granules, and we set generous sumps with strainers flashed into the field so water leaves before it freezes.
Snow Dumping Off the Upper Roof
Plenty of buildings here have a pitched section shedding straight onto the low slope below. We reinforce that landing zone with a protection layer and heavier membrane, so eight winters of sliding snow and ice do not abrade a hole in it.
Shade Growth Washes Off
North facing roofs under a heavy canopy stay damp, and moss, algae and oak tannin stain whatever they sit on. A PVC field can be washed on a low pressure setting without stripping granules, so the surface cleans up instead of degrading.
How We Run an Andover Job
Staging Fits the Parcel, Not the Truck
Access here is not uniform. Some sites sit tight to a parking bay, others on unsewered lots of two acres or more with a septic drainfield we cannot roll a loaded truck across. Crane, container and lay down spots get chosen before the first roll arrives.
We Map the Tree Line First
Before the membrane gets specified, we look at what overhangs the deck: dead oak limbs, low branches rubbing a parapet, and the corner where litter always collects. Some of that is a trimming conversation with you, not a roofing one.
Cold Weather Work Has Rules
Welding works in a Minnesota winter, but only on a dry deck, with weld speed and temperature adjusted and every seam probed by hand. Snow cover or ice stops us outright, and we would rather hold your building with repairs than rush a bad weld.
The Old Roof Leaves in One Trip
Tear off waste goes straight into the container, the container leaves when the roof is finished, and the lot gets swept with a rolling magnet each evening. Nobody should find a fastener in a tire in March because a crew was careless in October.
Family Run, Faith Based and Reachable
Ours is a family business, licensed and insured, working out of Eden Prairie across Andover, Blaine, Coon Rapids and Ramsey, holding a 5.0 rating from 217 Google reviews. The phone is staffed overnight, which matters when a limb comes through at midnight.
What people near Andover say
We live in Eden Prairie. Orange did an excellent job on our siding replacement and provided great customer service all the way through.
Thomas DeSutterSiding replacement, Eden Prairie, MN Fantastic guys to work with, did an excellent job of fixing our siding. You can tell it’s a high integrity company. Definitely recommend.
Carolyn MillerSiding repair The crew arrived early and spread tarps all around the house to capture every bit of debris. By 3:00 PM, my entire roof was completely finished.
Hazel JamesRoof replacement, Minneapolis, MN
Andover PVC Questions
What people in Andover ask us about this work. If yours is not covered, call and ask.
How do the oak trees over an Andover building affect a PVC roof?
Two ways, and only one of them is obvious. Limbs from oaks killed by oak wilt are a puncture risk, so near the canopy edge we specify reinforced membrane and tighter fastening. The quieter problem is litter, because a mat of wet leaves dams a drain and holds water on the deck straight through a freeze. We size drainage generously and check strainers each fall on shaded buildings.
Can PVC go over the low slope section of a metal pole building?
Frequently, yes. Shops and equipment buildings around Andover often have a low slope tie in or an addition where the panels never drained properly. We can set rigid board over the existing panels, fill the flutes and weld PVC across the whole plane, so there are no exposed fasteners left to back out. The panels have to be sound and dry underneath, which we verify before quoting.
What drives the price of a PVC roof on an Andover building?
Five things, mostly. How many layers have to come off, whether the insulation under them is wet, how many curbs and drains need individual flashing, how hard the site is to reach with a crane, and how much of the work has to happen outside your business hours. We do not quote by the square foot over the phone, because two buildings of the same size can be very far apart on all five.
Book an Andover Roof Walk
Call (612) 600-8529 any hour, any day, for a free estimate on PVC commercial roofing. We will get on the deck, map the exhaust and the tree line, and tell you plainly whether what you have up there can finish the season.
Get Your Free Exterior Estimate
Tell us what is going on with your roof, siding, windows, or gutters. We will take a look and give you a straight answer, including when the answer is that you can wait.
- Phone(612) 600-8529
- Emailadmin@orange-exteriors.com
- Office6600 City West Pkwy Suite 375, Eden Prairie, MN 55344
- HoursOpen 24 hours, Sunday to Saturday
Request your estimate
Rated 5.0 from 217 Google reviews